Page 16 - Warranty Service Book - Truck (v5.1)

SERVICE RECOMMENDATIONS

General Vehicle Maintenance Considerations engine oil consumption may be considered stabilised after the
The overall state of the vehicle is an important factor, which has first 5,000 km depending on the driving style.
a marked influence over fuel consumption and driving comfort
and on the life span of your vehicle. For this reason, care should WARNING: Engine Oil
be taken to maintain your vehicle by carrying out the necessary
checks and adjustments in accordance with specifications Engine oil consumption depends on the
given in the "Scheduled Maintenance Program" as well as the manner of driving, the conditions of use of
recommendations for use in the New Zealand market. Service the vehicle and the type of oil used. Always use the oil specified
intervals are set at maximum limits and must be performed in the "Technical Data" Section of your User's Manual.
before that mileage/time has been reached.
Checking Engine Oil
Additional Operations The engine oil should be checked with the vehicle on a level
Every 1,000km or before a long journey, check the following: surface several minutes after switching the engine Off.

▪ Engine oil level Remove the dipstick, clean it, put it back completely. Remove it and
▪ Coolant level check that the level is within the MIN and MAX marks on the dipstick.
▪ Brake/clutch fluid level (This corresponds to about one litre of oil.)
▪ Battery electrolyte level If the oil level is near or even below the MIN mark, add oil through
▪ Tyre pressure & condition (refer to Tyres on next page) the filler neck, until reaching the MAX mark.
▪ Fluid level in the windscreen wiper and in the headlamp
washer reservoir WARNING: After topping up the oil, run the engine for a few secs,
then turn it off, wait a few mins and check the level again.
Refer to '"Technical Data" in your User's Manual for the correct
type and quantity of fluids and oils. WARNING If a check reveals that the level is above the MAX
mark, contact your Foton Dealer and have the correct level restored,
Engine Oil Consumption as engine and component damage may result.
Max. allowable engine oil consumption is up to 1.5L every 1000km. For diagrams demonstrating the fill points and dipstick markings,
During the initial period of use the engine settles, therefore refer to your User’s Manual.

WARRANTY & SERVICE INFORMATION 14