Page 163 - 2006 HARLEY FLSTCI SERVICE MANUAL

Engine will not crank. DIAGNOSIS. NO displayed. No codes displayed. For symptoms that may not set diagnostic trouble codes, refer to table 5-2, Table 5-3 and Table 5-4. NO Locate and repair open between terminal 7 and ground.
NO. See 1.2 STARTING SYSTEM No DTCs

1 NO Check for continuity to ground on terminal 7 of speedometer. Wiggle harness during con- tinuity check. Continuity present? NO Locate and repair open between terminal 5 and battery fuse.
See 4.9 ENGINE CRANKS, BUT WILL NOT START.

Cranks, but will not start.
NO. NO Unable to enter diagnostic mode. With ignition switch OFF, press and release odometer reset switch. Does odometer display appear with display backlighting? YES Check for battery voltage at terminal 5 of speedometer while wiggling harness. Bat- tery voltage continuously present? NO Replace speedometer reset switch.

Does engine start? 2 YES With ignition switch OFF and speedometer connector [39] disconnected, check continuity between Breakout Box cavities 8 and 11 Is continuity present when speedometer reset switch is depressed and infinity when released?

Starts, then See 4.10 STARTS, THEN
YES. stalls. STALLS. YES STOP Go to Initial Diagnostic Check (Part 2 of 3). YES Replace speedometer.
Initial Diagnostic Check (Part 1 of 3)

Starts and YES All DTCs are listed on page 4-8 in 2006 Softail: Engine Management (Carbureted)
YES. runs. Check for diagnostic trou- ble codes (DTCs). See 4.5 SPEEDOMETER SELF DIAGNOSTICS DTCs found? Refer to applicable DTC priority chart. Table 4-5. DTCs are listed by priority.

HOME 4-10