Page 893 - Foton Workshop Manual - Aumark (BJ1099)
P. 893
TRANSMISSION - TRANSMISSION ASSEMBLY 21B-7
REPLACEMENT
NOTICE:
Caution: The transmissions of 4WDand 2WD vehicles are replaced in the same way.
Below the introduction is made by taking the 2WD vehicles as the example, and difference
with the 4WD vehicles will be given.
1. Park the vehicle on a level ground, apply the parking brake, and engage the “P”
gear.
2. Disconnect the battery negative cable (refer to “Chapter 18 Starting and charging -
Replacement, battery”).
3. Raise the vehicle.
4. Screw out the transmission bottom drain
plug and discharge the transmission
lubricating oil.
NOTICE:
• Before discharge, make sure that the vent plug
is unostructed.
•When discharging the transmission lubricating
oil, use a dedicated vessel to receive the
transmission lubricating oil, and dispose it as
required. 21B
fuwx21B008
•After the transmission lubricating oil is
discharged, refit the drain plug, and avoid
forgetting this.
Torque:12 N•m
5. Remove the transfer case assembly (refer to “Chapter 23 Transfer case -
Replacement, transfer case).
6. Remove the transmission assembly.
(a). Screw out the connecting bolt between the
rear propeller shaft universal joint and the
transmission flange plate assembly.
fuwx21B009
Page 893