Page 1098 - 2006 HARLEY FLSTCI SERVICE MANUAL

8.28 8-59

2006 Softail: Electrical
4

3 Figure 8-71. Fuel Gauge (Carbureted): Typical

1 2
Wiring harness Connector [117]

Gauge Gasket
s0598x8x 1. 2. 3. 4.

The fuel gauge is mounted in a simulated left fuel tank
See Figure 8-71. Three wires attach to the bottom of the
The fuel gauge sending unit is under a console on the
cap. Remove by gently pulling upward. Do not twist.

1WARNING 1WARNING prevent accidental vehicle start-up, which could cause death or serious injury, disconnect negative (-) NOTE The gauge wires are routed through a tube in the tank and 1WARNING 1WARNING Stop the engine when refueling or servicing the fuel sys- tem. Do not smoke or allow open flame or sparks near gasoline. Gasoline is extremely flammable and highly explosive, which could result in death or serious injury. Check to be sure fuel supply valve is in OFF position. Remove fuel line from the fuel supply valve. Drain fuel into an adequately sized, approved gasoline container. Remove fuel tank fastene

FUEL GAUGE gauge (1). middle of the tank. Remove seat. battery cable before proceeding. (00048a) Disconnect negative battery cable. are secured at the bottom of the tank. tor [117] and remove terminals. Do not twist gauge and wiring during removal.

HOME GENERAL ● ● ● REMOVAL 1. To 2. (00002a) 3. 4. 5. 6. tank. 7.