Page 188 - 2107 N Rough Creek Builder Binder for Owner.pdf

INSTALLATION

7 Turn the cold water supply 11 Disconnect the water pipes. 2 Install a suitable drain pan
that is piped to an adequate
valve OFF.
Many water pipes are
connected by a threaded drain.
Open the drain valve on the union which can be disconnected with
8 water heater. wrenches. If you must cut the water Set the water heater in place
pipes, cut the pipes close to the water 3 taking care not to damage
ons, the drain pan.
leaving the water pipes as long as
possible. If necessary, you can make NOTICE: Most codes require se ng
them shorter later when you install the water heater in a suitable drain
the new water heater. pan piped to an adequate drain. The
drain pan helps avoid property dam-
12 Remove the old water heater. age which may occur from condensa-
on or leaks in the piping connec ons
Figure 10 - Draining the old water heater. or tank. The drain pan must be at
Also open a hot water faucet WARNING! Use two or more people least two inches wider than the diam-
9 to help the water in the tank to remove or install water heater. eter of the water heater. Install the
drain faster. Failure to do so can result in back or drain pan so the water level is limited
other injury.
When the tank is empty, Step 4: Verify that the water heater
10
INSTALLATION discharge pipe. You may be able to Installing the new 4 is properly set in place. Check
disconnect the Temperature &
Pressure (T&P) Relief Valve

that:
water heater
reuse the discharge pipe, but do not
reuse the old T&P Relief Valve. A new
contact with any electrical parts.
Completely read all instruc-
T&P Relief Valve comes installed on
ons before beginning. If you
your water heater (or on some models,
is in the carton with the water heater). 1 are not sure if you can the T&P Relief Valve discharge pipe
complete the installa on, DO NOT and that it can be piped to a sepa-
RETURN THIS UNIT TO THE STORE. rate drain (and not into the drain
Seek assistance from any of the pan).
following sources:
around the water heater for future
a qualified person to install your maintenance.
water heater.

line at 1-800-821-2017

Figure 11 - Removing the T&P Relief Valve
discharge pipe.

al Electric Water Heater Use and Care Guide