Page 1062 - 2006 HARLEY FLSTCI SERVICE MANUAL

8.16 8-23

2 2 2006 Softail: Electrical
3
1 Figure 8-26. Main Circuit Breaker 1 3 Figure 8-27. Voltage Regulator Bracket

Voltage regulator wire Wire from ignition switch Silver terminal post Ground wire connection

s0562x8x 1. 2. 3. 7898 Bracket 1. 2. Bolt (2) 3.

VOLTAGE REGULATOR

1WARNING 1WARNING prevent accidental vehicle start-up, which could See Figure 8-26. See 8.4 ELECTRICAL PANEL to gain Disconnect the voltage regulator lead (1) from the main If replacing regulator, see Figure 8-27. Remove two bolts (3) to detach regulator from bracket (1). Detach If temporarily removing regulator and bracket, see Figure 8-28. Remove two bolts (6) to free bracket (7) See Figure 8-28. Disengage Deutsch connector (1) [46] from back of regulator bracket. Separate connector
NOTE The voltage regulator cannot be repaired. Replace the unit if it fails. For diagnostic information see Softail Models Electri- cause death or serious injury, disconnect negative (-) battery cable before proceeding. (00048a) Disconnect negative battery cable. access to main circuit breaker. Remove nut from silver terminal post. Remove ignition switch wire. Remove voltage regulator wire. NOTE Before removing voltage regulator wires, carefully note wire routing. In particular pay close attention to the locations of cable straps that must be replaced to keep wires from being Detach regulator from engine. ground wire (2) from br

REMOVAL cal Diagnostic Manual Remove seat. circuit breaker. damaged by vibration. from engine. halves.

HOME 1. To 2. 3. 4. a. b. c. 5. a. b. 6. 7.