Page 1261 - 2006 HARLEY FLSTCI SERVICE MANUAL

NOTE After setscrew is tightened, it is not necessary, nor desirable, to completely remove setscrew to adjust housing. Loosen setscrew 1/8 turn, adjust housing and tighten setscrew to 50- 60 in-lbs (5.7-6.8 Nm). Nylon lock pellet on setscrew main- tains locking ability after many adjustments. If set screw is Hold each bullet housing and tighten jam nut (8). Adjust the wire conduits inside and outside the housings to avoid pinching the wires. Tighten the housing fasten- Connect negative battery cable to battery. 11WARNING 1WARNING After installing seat, pull upward on front of seat to be sure it is in locked position. While riding, a loose seat can s
completely removed, replace. 12. 13. ers to 35-45 in-lbs (4-5 Nm). 14. or serious injury. (00070a) Install the seat. 15. 16. 1. cleaner, if necessary. 2. from lamp. 3. remove. 4. up socket assembly until free. 5. 6. 7. wires on old socket assembly. 8. 1. socket with slot in isolator. 2. 3. 4. inside lamp. 5.

NOTE For instructions on crimping terminals, see APPENDIX B- WIRING AMP MULTILOCK ELECTRICAL CONNECTORS in Attach mechanics wire to socket terminals and carefully pull ends of mechanics wire to draw socket terminals and Carefully remove mechanics wire to avoid damage to ter- Install terminals into socket housing. For correct terminal NOTE Replacement turn signals and socket assemblies may have turn signal wires with color code different from that shown in Table 8-1. Check pin half of connector [31A] to determine Loosely install housings over lever brackets and clamp. Assemble right turn signal bracket (11) to mirror and small washer with new lock wa

Softail Service Manual. wires back through conduit. minals. locations refer to TABLE 8-1. proper connection. Install right front turn signal: nut (10). from inboard side. bracket (11). Install left front turn signal: nut (10). from inboard side. bracket (3). motorcycle. vehicles to the rear of the motorcycle. 6.8 Nm).

HOME 3. 4. 5. 6. 7. a. b. c. d. e. f. 8. a. b. c. d. e. f. 9. 10. 11. 8-4