Page 248 - 2006 HARLEY FLSTCI SERVICE MANUAL

5-29

Incorrect pressure. See 5.15 NO Open in Y/GN wire between splice for fuel pump wire and ignition coil. Repair open.

NO FUEL PRESSURE TEST. Clear codes using speedometer self diagnostics. SPEEDOMETER SELF DIAGNOSTICS. 5.6 Confirm proper operation with no check engine 2006 Softail: Engine Management (EFI)

Continued from Test 5.10 (Part 1 of 4). Install fuel pressure gauge (Part No. HD-41182). See 5.15 FUEL PRESSURE TEST. While cranking engine (for more than 2 seconds to ensure proper system operation), verify that fuel pressure rises to 55-62 PSI (380-427 kPa). Adequate fuel pressure present? NO Check battery voltage at Terminal A (+) of coil connector [83B] using DVOM. Battery voltage present for 2 seconds 5 after key ON? YES NO Correct problems with fuel injectors. See 5.23 STOP DTC P0261, P0262, P0263, P0264. Go to Test 5.10 (Part 3 of 4). NO See 5.16 IDLE AIR CONTROL. NO

Test 5.10 (Part 2 of 4) ENGINE CRANKS, BUT WILL NOT START YES Check spark plug condition, replace if fouled. Reinstall spark plugs before checking spark. Check spark at both plugs while cranking. Spark present? YES Verify connector is securely attached to each injector. If so, disconnect fuel injector connector and attach fuel injector test lamp (HD-34730-2C. Crank engine. Does lamp flash? YES Monitor IAC pintle for 10 seconds after turning ignition OFF . Does pin- tle extend and then retract during 10 second key OFF reset procedure? YES Check for plugged fuel injectors. Injectors plugged?

HOME 4 6