Page 1204 - 2006 HARLEY FLSTCI SERVICE MANUAL

step three times or more until only a steady flow of clutch
fluid escapes banjo fitting and fluid level in reservoir is at
Cover exhaust with towel and place a suitable pan under
Fill reservoir to FILL LEVEL and repeat the previous
FILL LEVEL with motorcycle in an upright position.
clutch release cover to catch excess clutch fluid.

While holding reservoir cover in place: Pump clutch hand lever 5 times. Watch bleeder valve for air bubbles. Tighten bleeder valve. Release hand lever. in an upright position. Do not overfill reservoir. Tighten fasteners as follows: (9-11.3 Nm). Replace cap on actuator bleeder valve. a. Dragging clutch. Hard shifting.

NOTE Dispose of clutch fluid in accordance with local regulations. Hold clutch hand lever against handlebar. Loosen secondary clutch actuator bleed valve. Run hose from bleeder valve to suitable container. With reservoir level, fill reservoir to FILL LEVEL and repeat the previous step three times or more until only a steady flow of clutch fluid escapes bleeder valve and fluid level in reservoir is at FILL LEVEL with motorcycle CAUTION Clutch fluid volume actually increases with clutch wear. Test pressure by squeezing clutch hand lever. Actuator bleeder valve to 80-100 in-lbs Reservoir cover screws to 6-8 in-lbs (0.7-0.9 Nm). Test ride mot

4. 5. 6. a. b. c. d. e. f. g. 7. 8. 9. a. b. 10. 11. cause: b. RELEASE BEARING system operation.

Traction will be adversely

BLEEDING CLUTCH FLUID LINE

1WARNING 1WARNING Be sure NO clutch fluid gets on tires, wheels or brakes affected which could result in loss of control of the 1WARNING 1WARNING Do NOT allow foreign matter to enter the clutch master cylinder reservoir. Dirt or debris in the reservoir may cause improper operation of the clutch and equipment damage. This could result in loss of control of the motor- 1CAUTION Direct contact of D.O.T. 4 brake fluid with eyes can cause irritation. Avoid eye contact. In case of eye contact flush with large amounts of water and get medical attention. Swallowing large amounts of D.O.T. 4 brake fluid can cause digestive discomfort. If swallowed, obtain

when adding clutch fluid. motorcycle and death or serious injury. cycle and death or serious injury. REACH OF CHILDREN. (00240a) tially draw the fluid down the clutch line. reservoir cover. Do not overfill reservoir. stream several feet. Retighten banjo fitting. Release hand lever.

HOME 1. 2. 3. a. b. c. d. e. f.